Passat 3B5 PD130 Map [038906019EP]

by **djekl** » Sun Jul 17, 2016 6:17 pm

Hey, so after looking into mapping for a few years I finally have a project car to play with. However this was the map I pulled off of the "Economy Tuned" Passat. This is far from an Economy tune, and the torque map flat lines far too early, and I think the Boost maps are turned up too high.

Anyways I would like some advice on this map, maybe if anyone wants to have a play with it, smoothing it out etc. It comes off of an 038906019EP ECU, and like I said, any advice/help would be appreciated.

by **Houdini** » Sun Jul 17, 2016 7:51 pm

the boost isn't to high for the car, but this map is just shit. this is what you call a 5 min tune. best is to start from scratch.

by **djekl** » Sun Jul 17, 2016 7:56 pm

Thanks, I should have known with only getting 30MPG avg even on motorway.

Any suggestions on where to start? Tutorials, reading material etc.

by **wicca** » Mon Jul 18, 2016 10:03 am

If you can hold it down to 110 km/h on the highway/motorway, you should be able to do 52-53 MPG (18,5-19 km/l) on this engine, if the map is nice in the low- and midzone + combining it with adjustment of the timing belt to be slight positive.

by **Houdini** » Mon Jul 18, 2016 3:33 pm

there is a edc15 tuning guide floating around on the forum.

by **djekl** » Tue Jul 19, 2016 3:00 pm

OK so after some reading, and looking at my Friends PD130 tune (different ECU). I have made this file, before I put it on what do you guys think? I used a standard base map to begin with, and made changes to the following

- EGR (delete)
- Driver Wish
- Smoke Limiter
- Boost Target Map

I don't believe I missed anything.

by **sandor1987** » Tue Jul 19, 2016 5:19 pm

driver wish dont need to be change because limit is 70mg and durations are 55mg.
de rest looks good to me ;)

in boostmap 4x4 you change in de middle highter boost?? :lol:

130tdi can easy do 160 a 170HP and 400nm with durations en good adjustment ;)

by **djekl** » Tue Jul 19, 2016 5:29 pm

sandor1987 wrote:driver wish dont need to be change because limit is 70mg and durations are 55mg.
de rest looks good to me ;)

in boostmap 4x4 you change in de middle highter boost?? :lol:

130tdi can easy do 160 a 170HP and 400nm with durations en good adjustment ;)

What would I change to increase the durations from 55mg? The injection duration?

Also, the 4x4 map is default. I have only modified the 1st code block (manual).

I would be interested to see what modifications you would make to this map if possible?